RESUMO
AIM: In this study, the biological variation for improvement of the nutritive value of wheat straw by 12 Ceriporiopsis subvermispora, 10 Pleurotus eryngii and 10 Lentinula edodes strains was assessed. Screening of the best performing strains within each species was made based on the in vitro degradability of fungal-treated wheat straw. METHODS AND RESULTS: Wheat straw was inoculated with each strain for 7 weeks of solid state fermentation. Weekly samples were evaluated for in vitro gas production (IVGP) in buffered rumen fluid for 72 h. Out of the 32 fungal strains studied, 17 strains showed a significantly higher (P < 0·05) IVGP compared to the control after 7 weeks (227·7 ml g-1 OM). The three best Ceriporiopsis subvermispora strains showed a mean IVGP of 297·0 ml g-1 OM, while the three best P. eryngii and L. edodes strains showed a mean IVGP of 257·8 and 291·5 ml g-1 OM, respectively. CONCLUSION: Ceriporiopsis subvermispora strains show an overall high potential to improve the ruminal degradability of wheat straw, followed by L. edodes and P. eryngii strains. SIGNIFICANCE AND IMPACT OF THE STUDY: Large variation exists within and among different fungal species in the valorization of wheat straw, which offers opportunities to improve the fungal genotype by breeding.
Assuntos
Ração Animal/microbiologia , Fungos/isolamento & purificação , Triticum/microbiologia , FermentaçãoRESUMO
AIM: This study evaluated differences between two strains of Ceriporiopsis subvermispora on improving the nutritive value and in vitro degradability of wheat straw. METHODS AND RESULTS: Wheat straw was treated with the fungi for 7 weeks. Weekly samples were analysed for ergosterol content, in vitro gas production (IVGP), chemical composition and lignin-degrading enzyme activity. Ergosterol data showed CS1 to have a faster initial growth than CS2 and reaching a stationary phase after 3 weeks. The IVGP of CS1-treated wheat straw exceeded the control earlier than CS2 (4 vs 5 weeks). CS1 showed a significantly higher (P < 0·001) selectivity in lignin degradation compared to CS2. Both strains showed peak activity of laccase and manganese peroxidase (MnP) at week 1. CS1 showed a significantly higher (P < 0·001) laccase activity, but lower (P = 0·008) MnP activity compared to CS2. CONCLUSION: Both CS strains improved the nutritive value of wheat straw. Variation between strains was clearly demonstrated by their growth pattern and enzyme activities. SIGNIFICANCE AND IMPACT OF THE STUDY: The differences among the two strains provide an opportunity for future selection and breeding programs in improving the extent and selectivity of lignin degradation in agricultural biomass.
Assuntos
Coriolaceae/metabolismo , Ruminantes/metabolismo , Triticum/microbiologia , Ração Animal/análise , Animais , Biomassa , Coriolaceae/classificação , Coriolaceae/enzimologia , Coriolaceae/genética , Proteínas Fúngicas/genética , Proteínas Fúngicas/metabolismo , Lacase/genética , Lacase/metabolismo , Lignina/metabolismo , Valor Nutritivo , Peroxidases/metabolismo , Caules de Planta/metabolismo , Caules de Planta/microbiologia , Ruminantes/crescimento & desenvolvimento , Triticum/metabolismoRESUMO
In ruminant nutrition, there is an increasing interest for ingredients that do not compete with human nutrition. Ruminants are specialists in digesting carbohydrates in plant cell walls; therefore lignocellulosic biomass has potential in ruminant nutrition. The presence of lignin in biomass, however, limits the effective utilization of cellulose and hemicellulose. Currently, most often chemical and/or physical treatments are used to degrade lignin. White rot fungi are selective lignin degraders and can be a potential alternative to current methods which involve potentially toxic chemicals and expensive equipment. This review provides an overview of research conducted to date on fungal pretreatment of lignocellulosic biomass for ruminant feeds. White rot fungi colonize lignocellulosic biomass, and during colonization produce enzymes, radicals and other small compounds to breakdown lignin. The mechanisms on how these fungi degrade lignin are not fully understood, but fungal strain, the origin of lignocellulose and culture conditions have a major effect on the process. Ceriporiopsis subvermispora and Pleurotus eryngii are the most effective fungi to improve the nutritional value of biomass for ruminant nutrition. However, conclusions on the effectiveness of fungal delignification are difficult to draw due to a lack of standardized culture conditions and information on fungal strains used. Methods of analysis between studies are not uniform for both chemical analysis and in vitro degradation measurements. In vivo studies are limited in number and mostly describing digestibility after mushroom production, when the fungus has degraded cellulose to derive energy for fruit body development. Optimization of fungal pretreatment is required to shorten the process of delignification and make it more selective for lignin. In this respect, future research should focus on optimization of culture conditions and gene expression to obtain a better understanding of the mechanisms involved and allow the development of superior fungal strains to degrade lignin in biomass.
Assuntos
Ração Animal , Biomassa , Fungos/metabolismo , Lignina/química , Ruminantes , Agaricales/metabolismo , Animais , Celulose/química , Fenômenos Químicos , Técnicas de Cultura , Digestão , Aditivos Alimentares , Células Vegetais/química , Polissacarídeos/químicaRESUMO
Maize stover, rice straw, oil palm fronds and sugarcane bagasse were treated with the white-rot fungi Ceriporiopsis subvermispora, Lentinula edodes, Pleurotus eryngii, or Pleurotus ostreatus at 24 °C for 0-6 weeks. The fungi increased total gas production from oil palm fronds by 68-132%, but none of the fungi improved the in vitro rumen fermentability of maize stover. C. subvermispora and L. edodes increased total gas production of sugarcane bagasse by 65-71%, but P. eryngii and P. ostreatus decreased it by 22-50%. There was a linear relationship (P<0.05) between the proportion of lignin in the original substrate and the increase in in vitro gas production observed for C. subvermispora and L. edodes treatments (R2=0.92 and 0.96, respectively). It is concluded that C. subvermispora and L. edodes have a particularly high potential to improve the nutritive value of highly lignified ruminant feeds.
Assuntos
Agricultura/métodos , Ração Animal/microbiologia , Manipulação de Alimentos/métodos , Fungos/metabolismo , Resíduos Industriais/prevenção & controle , Plantas/microbiologia , Rúmen/microbiologia , Animais , Biodegradação AmbientalRESUMO
Eleven white-rot fungi were examined for their potency to degrade lignin and to improve the rumen fermentability of wheat straw. The straw was inoculated with the fungi and incubated under solid state conditions at 24°C for 0-49 days to determine changes in in vitro gas production and chemical composition. Results show that some fungi could degrade lignin by as much as 63%, yet the delignification was highly correlated with the degradation of hemicellulose (r=0.96). Reduction in lignin was poorly (r=0.47), but the ratio between lignin and cellulose loss was strongly (r=0.87) correlated with the increase in gas production. Treatment with Ceriporiopsis subvermispora for 49 days increased total gas production of the straw from 200 to 309 ml/g organic matter (OM). It was concluded that some fungi highly selective for lignin and not for cellulose are able to improve the nutritive value of wheat straw as a ruminant feed.